DO88 Performance – S60/V70II 2003-2007 Petrol Turbo DO88 Intercooler/Pipekit – BIG-X70-UG

DO88 Performance – S60/V70II 2003-2007 Petrol Turbo DO88 Intercooler/Pipekit – BIG-X70-UG

DO88.se Performance Intercooler/Pipe Kit (Big Pack)

To Fit: Petrol turbo Models

S60 from 2003 to 2009

V70II from 2003 to 2007

S60R 2005-2007- only fits later cars with plastic over engine pipe

V70R 2005-2007 -only fits later cars wtih plastic over engine pipe

XC70 2003-2007

do88 performance intercoolers are an all aluminium construction with cad designed, flow optimized cast end tanks and core design to achieve best possible cooling efficiency combined with lowest possible pressure drop. The OEM intercooler was designed for the power level the car was built with and a power increase or even very hard use of the car in a standard version may cause that the OEM intercooler does not have the performance you need. So after only a software tune the do88 performance intercooler will give a performance increase over the OEM intercooler.

Significant advantages with do88 performance intercooler against (OEM intercooler):

– Core volume: 13068cm3 (8659cm3), do88 is 51% larger!

– Air flow at 0,15bar/2,18psi pressure drop: 319CFM (272CFM), do88 17% higher

– Post intercooler air temperature at same conditions: 30?C (54?C), – do88 24?C lower!

A common misunderstanding is that an intercooler installed in this position cannot provide good performance and a front mounted intercooler / FMIC would be much better. But actually the do88 performance intercoolers are far better than most FMIC installations where only a core with small front surface are possible to install and often also installed partially behind the bumper beam which will reduce cooling capacity even further, often resulting in cooling ability worse than the OEM intercooler! This intercooler fits all Volvo S60 / V70 / XC70 / S80 turbo models with or without sensor on the intercooler outlet as it has a mounting plate but also includes a block off plate that will be used only on cars without a sensor mounted on the intercooler outlet.The do88 performance intercooler installs into the original position, with original fixings. The OEM intercooler has plastic tanks that often do not cope with higher boost levels very well so the do88 performance intercooler will also add reliability.

HFD = High Flow Design by do88. Intercooler Pipe Kit in alloy that replaces the OEM plastic pipes!

These pipes have a larger diameter compared to OEM pipes for improved airflow! Everything is included in this kit to replace both upper and lower intercooler pipes.

NOTE! When installing this performance intercooler on a S60 R / V70 R the small auxiliary intercooler needs to be removed as it no longer will be used. On R-models the centre bumper grille is a part of this auxiliary intercooler. This means when you remove the original part you will have to install a new mesh in this opening. You dont have to install a mesh, but if you dont do this the bumper intake hole will just be open onto the AC-condenser and it may suffer damage from road debris or stones whilst driving.

When ordering please specify blue, black or red hoses

DO88 reference BIG-X70-UG

Contact Us for further Information by filling out this FORM

Be sure to follow our Instagram page for new offers and the latest products @Partspluguk